B737-Fuel Systems Summary

Smartcockpit.com

BOEING 737 SYSTEMS REVIEW

Page 1

FUEL

1. GENERAL ¡ Fuel is contained in three tanks located within the wings and wing center section.

Main tanks No. 1 and No. No. 2 are integral with with the wing structure. structure. The center tank ¡ There a 3 tanks : Main lies between the wing roots within the fuselage area and extends out into the wing structure. ¡ Each tank is equipped with two electrical fuel boost pumps which supply fuel directly to the

respective engine or to both engines through the f uel crossfeed valve. engine-driven fuel fuel pumps also provide suction suction fuel feed from the two main tanks. Fuel ¡ Mechanical engine-driven for APU operation is normally supplied from the left side of the fuel manifold.

2. FUEL FEED ¡ Two AC powered fuel pumps, which are fuel cooled and lubricated, are installed for each fuel tank.

B737 Classics : A single generator failure will only affect one pump in each tank. ¡ Individual pressure sensors monitor the output pressure of each pump. ¡ The engine-driven fuel pumps provide suction feed in the event that normal electrical fuel pump

operation is not available. The engine pumps draw fuel through bypass valves located in main tanks No. 1 and No. 2. No bypass valve is available available in the center tank. The main tank bypass valves may also be used for suction defueling. ¡ The engine fuel shutoff valves (at each engine-mounting wing station) and 737 NG spar valve are DC

motor operated from the the hot battery bus. They close whenever whenever the respective Engine Engine Fire Warning Switch is pulled or the Engine Start Lever is placed to CUTOFF. ¡ The engine fuel manifolds are interconnected by the crossfeed valve directing fuel to both engines

from any tank. The valve is DC motor motor operated from from the battery bus. ¡ Check valves ensure the proper direction of fuel flow and prevent transfer of fuel between tanks.

- 737 Classics : Center tank check valves open at a lower differential pressure than the check valves in main tanks No. 1 and No. 2. - 737 NG : Center tank pumps produce higher pressure than main tank pumps. This ensures that center tank fuel is used before main tank fuel, even though all fuel pumps are operating. ¡ When AC fuel pumps are operating, fuel for the APU is supplied from the left side of the fuel manifold.

If the AC fuel pumps are not operating, fuel is suction fed from main tank No. 1.

Copyright © Smartcockpit.com Ludovic ANDRE / version 00

Smartcockpit.com

Page 2


3. CENTER TANK SCAVENGE JET PUMP 737 Classics ¡ When both Center Tank Fuel Pump Switches are turned OFF, the fuel scavenge shutoff valve opens. This allows fuel from the main tank No. 1 forward pump to operate the Center Tank Scavenge Jet Pump, which transfers the remaining center tank fuel to main tank No. 1. After 20 minutes, the fuel scavenge shutoff valve automatically closes. ¡ When any Center Tank Fuel Pump Switch is subsequently recycled ON then OFF, the Center Tank Scavenge Jet Pump will again be operated for 20 minutes. 737-800 ¡ The center tank fuel scavenge jet pump begins to operate when the No. 1 main tank is about 2/3 full and the main tank No. 1 forward pump is operating. Once the fuel scavenging process starts, it continues for the remainder of the flight.

4. FUEL VENT SYSTEM ¡ The purpose of the fuel vent system is to prevent damage to the wings due to excessive buildup of

positive or negative pressure inside the fuel tanks and to provide ram air pressure within the tanks. The tanks are vented into surge tanks which vent through a single opening at each wing tip.

5. FUEL TEMPERATURE ¡ A sensor in main tank No. 1 allows monitoring of fuel system temperature.

The temperature

indicating system uses AC electrical power.

6. TANK CAPACITY USEABLE FUEL 737 Classics TANK No. 1 No. 2 Center tank TOTAL

LITERS 5667 5667 8743 20077

WEIGHT (kg) 4530 4530 7000 16060

TANK No. 1 No. 2 Center tank TOTAL

LITERS 4876 4876 16273 26025

WEIGHT (kg) 3900 3900 13020 20820

737 NG

The above figures are approximate amounts of fuel. The appropriate weight and balance control & loading manual gives exact figures for all configurations. Fuel density used - 0.80 kg / liter.



Smartcockpit.com

Page 3

7. FUELING / DEFUELING / GROUND TRANSFER ¡ Fueling and defueling is accomplished at the fueling station in the right wing. The fueling station is

also used for the ground transfer of fuel between tanks. ¡ A shutoff system automatically closes the fueling valve in each fuel tank when the tank is full. ¡ 737 Classics : Overwing fueling receptacles for main tanks No. 1 and No. 2 are provided for gravity

fueling. Center tank servicing can only be accomplished through the ground tank-to-tank fuel transferring operation. ¡ The manual defueling valve interconnects the engine feed system and the fueling station.

It is opened for defueling and tank-to-tank transfer operations.

8. CONTROLS & INDICATORS Fuel Control Panel IN DICATOR ¡ TEMPERATURE INDICATOR : Indicates fuel temperature in main tank No. 1. ¡ CROSSFEED SELECTOR : controls the fuel crossfeed valve.

When in OPEN position : connects the engine No. 1 and No. 2 fuel feed lines. ¡ FUEL PUMP SWITCH ON : activates the fuel pump.

Fuel Quantity Indicators ¡ FUEL QUANTITY INDICATOR

ILLUMINATED (white): - Indicates useable fuel in the related tank. - Accuracy is 2.5% of full scale reading - Standby AC power is required. ¡ FUEL QUANTITY TEST SWITCH (B737 Classics only) : used for maintenance purposes only. ¡ ERROR INDICATOR

ERR : - Appears with associated error codes whenever a malfunction occurs. - Used normally for maintenance purposes only. ERR CODE 1 2 3 4 5 6 7 8 9 10

FQI Reading

Probable cause

Normal zero Normal Zero Zero Normal *(1) Blank *(1) Zero

Open or short Short in compensator Excessive compensator unit leakage Open circuit Short in tank unit Excessive tank unit leakage Calibration unit failure Error in DCTU data Indicator Memory failure Open or short

*(1) - if failure occurs during flight indicator reading will be normal with ERR shown - if failure occurs when power is applied, the FQI will read zero with ERR shown Copyright © Smartcockpit.com Ludovic ANDRE / version 00

Smartcockpit.com


Page 4

¡ LOW FUEL INDICATION (B737 NG only )

ILLUMINATED (amber): - Fuel quantity is less than 907 kg (2000 lbs) in related main tank. - Fuel quantity arc and digits on tank(s) with low fuel quantity turn amber. - Displayed until quantity is increased to 1134 kg (2500 lbs). ¡ FUEL CONFIGURATION (CONFIG) INDICATION (B737 NG only )

ILLUMINATED (amber): - Center tank quantity greater than 726 kg (1600 lbs); both center tank pumps are producing low or no pressure and either engine is running. - Fuel quantity arc and digits on center tank turn amber. - Inhibited when center tank quantity is less than 363 kg (800 lbs). ¡ FUEL IMBALANCE (IMBAL) INDICATION (B737 NG only )

ILLUMINATED (amber): - Main tanks differ more than 453 kg (1000 lbs). - Fuel quantity arc and digits on tank with lower fuel quantity turn amber. - Inhibited on ground. - Inhibited by LOW fuel indication when both indications exist. - Displayed until imbalance is reduced to 91 kg (200 lbs) .

External Fueling Panel ¡ SOLENOID OVERRIDE (red)

- Mechanically opens the solenoid operated valve. - The fuel valve opens if fuel pressure is available. ¡ FUELING VALVE : With the Battery Switch ON, fuel pressure opens the valve, if energized. ¡ FUELING POWER CONTROL SWITCH

DOOR CLOSED :The proximity sensor deactivates power of the fueling system. DOOR OPEN : - The fueling system is powered. - The panel lights illuminate. ¡ FUELING VALVE POSITION LIGHT (blue)

EXTINGUISHED : - The fueling Valve Switch is in the open position and the associated tank is full. - The Fueling Valve Switch is in the closed position. ILLUMINATED : - The Fueling Valve Switch is in the open position and the associated tank is not full. ¡ FUELING VALVE SWITCH

OPEN : - Energizes the fueling valve. CLOSED : - De-energizes the fueling valve. ¡ FUEL QUANTITY INDICATOR : indicates total useable fuel tank quantity.


Smartcockpit.com


Page 5

Fuel Measuring Stick ¡ Either dripsticks or floatsticks are installed.

- Allows a comparison of fuel quantity or weight determined from the stick reading with the fuel weight indicated by the Fuel Quantity Indicators. - Five fuel measure sticks are installed in each main tank. ¡ DRIPSTICK:

A dripstick reading is obtained by withdrawing the dripstick from the tank until a steady drip of fuel commences at the drip hole near the base. ¡ FLOATSTICK :

- A floatstick reading is obtained by withdrawing the flexible floatstick scale from the tank until the scale ,"sticks" or "hangs". - The floatstick indication is read from the floatstick scale level with the lower wing skin and corrected for aircraft attitude via conversion/correction tables. Center Panel ¡ FUEL FLOW SWITCH

RATE : the digital fuel flow are displayed on both fuel flow indicators. They show rate of fuel Consumption (kg/hr or lbs/hr) USED : - displays fuel used per engine since last reset (B737 Classics) - displays fuel used per engine since last reset after l0 seconds , display automatically reverts to fuel flow if switch is activated longer than 30 sec, fuel used readout is deactivated for remainder of flight (B737 NG) RESET : - decreases readout to zero (B737 Classics) - resets fuel used to zero (B737 NG) displays fuel used for 1 second, decreases to zero, then displays fuel flow Note: failure of any N1, EGT, N2 or Fuel Flow indicator or transmitter results in the respective digital display blanking and the pointer moving to zero


Page 6


Smartcockpit.com

9. FAULTS & INDICATIONS VALID FOR LIGHT

ENG VALVE CLOSED

FUEL VALVE CLOSED

FILTER BYPASS LOW PRESSURE

INDICATION ENGINE VALVE CLOSED LIGHT (blue) EXTINGUISHED : - The engine fuel shutoff valve is open. ILLUMINATED (bright); - The engine fuel shutoff valve is in transit, or the position of the valve is not in agreement with the position of the associated Start Lever or Engine Fire Warning Switch. ILLUMINATED (dim): - The engine fuel shutoff valve is closed. FUEL VALVE CLOSED LIGHT (blue) EXTINGUISHED : - The engine fuel shutoff valve is open. ILLUMINATED (bright); - The engine fuel shutoff valve is in transit, or the position of the valve is not in agreement with the position of the associated Start Lever or Engine Fire Warning Switch. ILLUMINATED (dim): - The engine fuel shutoff valve is closed. FILTER BYPASS LIGHT (amber) - Indicates impending or actual filter bypass due to a contaminated filter. FUEL PUMP LOW PRESSURE LIGHT* (amber) * MAIN TANK FUEL ILLUMINATED : Fuel pump output pressure is low, or the Fuel Pump Switch is OFF.

300

X

400

X

500

600

700

800 900

X

X

X

X

X

X

X

X

X

X

X

X

X

X

X

X

X

X

X

NOTE : Two LOW PRESSURE Lights illuminated in the same tank will illuminate the MASTER CAUTION and FUEL System Annunciator Lights. One LOW PRESSURE Light will cause the MASTER CAUTION and FUEL System Annunciator Lights to illuminate on MASTER CAUTION Light recall.

LOW PRESSURE

EXTINGUISHED : Fuel pump output pressure is normal. FUEL PUMP LOW PRESSURE LIGHT* (amber) * CENTER TANK FUEL ILLUMINATED: Fuel pump output pressure is low and the Fuel Pump Switch is ON. NOTE : - With both Center Tank Fuel Pump Switches ON, the illumination of both LOW PRESSURE Lights will illuminate the Master Caution and the FUEL System Annunciator Lights. The illumination of one LOW PRESSURE Light will illuminate the MASTER CAUTION and FUEL System Annunciator Lights on MASTER CAUTION Light recall. - With one Center Tank Fuel Pump Switch OFF, the illumination of the opposite Center Tank LOW PRESSURE Light will illuminate the MASTER CAUTION and Fuel System Annunciator Lights.

EXTINGUISHED : Fuel pump output pressure is normal.


Smartcockpit.com

SPAR VALVE CLOSED

Page 7

BOEING 737 SYSTEMS REVIEW SPAR VALVE CLOSED LIGHT (blue) EXTINGUISHED: - The spar valve is closed.

X

X

X

X

X

X

ILLUMINATED (bright): - The spar valve is in transit, or the position of the valve is not in agreement with the position of the associated Start Lever or Engine Fire Warning Switch. ILLUMINATED (dim): - The spar valve is open.

VALVE CLOSED

CROSSFEED VALVE CLOSED LIGHT (blue) EXTINGUISHED : - The crossfeed valve is closed. ILLUMINATED (bright): - The crossfeed valve is in transit, or the position of the valve is not in agreement with the position of the Crossfeed Selector. ILLUMINATED (dim): The crossfeed valve is open.


X

X

X

Smartcockpit.com


FUEL SCHEMATIC B737 CLASSICS


Page 8

Smartcockpit.com


FUEL SCHEMATICS B737 NG


Page 9

B737-Fuel Systems Summary

Recommend Documents